NHTSA Recalls

2005 Chevrolet UPLANDER

3 open or recent recalls

3 open recalls

Open recalls

Units affected

Trucks in our DB

Carriers in DB

What this means

3 open or recent NHTSA recalls affect the 2005 Chevrolet UPLANDER. Recall repairs are free at OEM dealers — but only if you take the truck in. If you operate this model, verify recall service status by submitting the VIN at the OEM dealer or via NHTSA.gov. Insurance underwriters and freight brokers increasingly ask carriers to confirm recall service is current before contract loads.

All 3 recalls for this vehicle

NHTSA Campaign

10V110000

0 affected

Issue: THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.

Fix: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.

NHTSA Campaign

05V287000

0 affected

Issue: CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.

Fix: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-97

NHTSA Campaign

05V061000

0 affected

Issue: ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.

Fix: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-80

Frequently Asked Questions

Will an open recall fail a DOT inspection on a 2005 Chevrolet UPLANDER?

An open recall does NOT automatically fail a Level 1, 2, or 3 DOT roadside inspection — those focus on brake, tire, light, HOS, and driver-fitness items. However, if the recall affects a safety-critical component that is showing visible defect (cracked brake line, leaking fuel line, etc.) and the inspector identifies the defect itself, it can result in an out-of-service violation. Best practice: complete recall service promptly to avoid the question entirely. Recall completion is free at the dealer.

How do I check if my specific VIN has open recalls?

Three ways: (1) Enter your VIN at NHTSA.gov/recalls — free, instant. (2) Call any Chevrolet dealer and provide your VIN — they'll look up open campaigns. (3) Use our VIN decoder tool at /vin/ which cross-references against our recall database. The fastest is the NHTSA site; the most useful for fleet operators is the dealer call (they can also schedule the repair on the spot).

Who pays for recall repairs?

The manufacturer pays. Recall service is free at any authorized OEM dealer regardless of the truck's age, mileage, or who owns it now. The exception: if recall service is more than 10 years old, some manufacturers can decline (rare on commercial trucks). Chevrolet/UPLANDER recall service typically takes 1–4 hours of dealer shop time depending on the campaign — usually no charge for parts or labor.

What's the difference between a recall and a TSB on a Chevrolet?

A recall (NHTSA campaign) is a manufacturer-mandated safety repair — free and required. A TSB (Technical Service Bulletin) is the manufacturer telling dealers about a known issue and the recommended fix, but TSB repairs are typically NOT free — owners pay parts and labor. Recalls fix safety risks; TSBs fix quality/reliability issues that aren't safety-related. If you're seeing a problem that ISN'T on the recall list, search TSBs for Chevrolet UPLANDER 2005 — there may be a documented fix.

Can I keep operating a 2005 Chevrolet UPLANDER with an open recall?

Legally yes (no federal law prohibits operating a vehicle with open recalls on a commercial truck — only some passenger-vehicle resale rules apply). Practically: depends on the specific recall. Safety-critical recalls (brakes, steering, fuel system) should be addressed immediately — both for safety and because insurance carriers and shippers increasingly track this. Less-critical recalls (lighting, infotainment) can wait until your next dealer visit. Always review the specific recall summary to understand severity.

Vetting a carrier? Talk to dispatch.

(682) 978-8641 Send a message

2005 Chevrolet UPLANDER

What this means

Related

Frequently Asked Questions

Vetting a carrier? Talk to dispatch.

Ready to Grow Your Trucking Business?